YZG、FZG真空干燥机 低温干燥 溶剂回收 特别适用于怕氧化的物料

'YZG、FZG真空干燥机

■ 原理 principle

◎ 水在沸腾状态时具有的汽化速度。常压下,约100℃时水开始沸腾。而在真空条件下，由于系统中水蒸汽分压,远低于物料 表面的水蒸汽分压,水的沸点低于100℃,例如：压力为-0.07Mpa时,水在70℃即开始沸腾,一般规律,真空度越高水的沸点越低。在 真空干燥器内,汽化后的水能随真空产生系统迅速排除,所以尽管在较低的操作温度下,本干燥器仍有较大的干燥能力。设备运行 时 ,物料处于静止状态,有利于保持物料的初始形态,间歇操作,能随时调整工艺条件,本设备均为人工装卸料。

◎ Pure water has the highest evaporation speed under boiling condition.under normal pressure,pure water starts to boil at the temperature of 100℃,e.g. when surface is at -0.07Mpa,the vacuum system,therefore,this drier has larger drying capability although it’s under lower operation temperature. Material is under static condition during operation of the equipment,which is benefit for keeping initial status of material,intermittent operation can adjust process conditions at any time.

■ 特点 FeAtUres

◎ FZG-15干燥器，顶部布置加热器系统，能有效克服凝结水返滴问题，并在侧面布抽吸吸爆气口（驱赶水气作用）进一步提高 了干燥效率。

◎ 设备既可用于低温干燥，又能用于溶剂回收，所用热源可为蒸汽，也可为热水，导热油。特别适用于干燥过程中怕氧化的物料。

◎ On the top of gzF-15 dryer,heating system is arranged to tackle the problem of return of condition water,in addition,air suction is arranged at the side to improve drying efficiency.

◎ this equipment can be used for low temperature drying and solvent recovery,heat source can be steam,hot water or heat conducting oil.specially suitable for material that is easily oxygenated during drying.

■ 流程图 Flow chArt

■ 技术参数 technicAl pArAMeters

名称\\规格YZG-600YZG-1000YZG-1400FZG-15箱内尺寸Φ600×976Φ1000×1527Φ1400×20541500×1220×1400箱外尺寸1153×810

×10201740×1226

×13852386×1657

×18002060×1513×1924烘架层数4688层间距离8198102122烘盘尺寸310×600×45460×640×45460×640×45460×640×45烘盘数4123232 干燥能力（烘盘数*2kg） 824 64 64 烘架管内允压≤0.784≤0.784≤0.784≤0.784箱内温度≤150≤150≤150≤150箱内空载真空度-0.1不用冷凝器时，真空泵型号、功率SK-0.8 1.5kwSK-3 2.2kwSK-3 4kwSK-3 4kw干燥箱重量25080014002100'