供应振动仓顶除尘器

仓顶除尘器又称水泥罐振动仓顶除尘器 （固安县博程除尘设备厂）根据水泥、粉煤灰、石粉、矿粉、化工粉等各种粉末状物质的通过孔径，设计收尘器的滤芯通过直径及附着力作用给滤芯孔径的影响作用，完全可以满足各粉末状物质过滤要求。即满足散装车风送及成装品拆散后风送的要求，又能保证在粉末物质使用时，仓内无负压。具有体积小，结构紧凑等优点。

易于安装等特点为了保障搅拌站的操作人员的安全，建议安装压力安全阀，这个是安全的***后的保障！产品基本属性： 产品型号Product modelFY-24FY-24过滤面积Filtration area24平方米24Sqm滤芯数量Cartridge number14支14排风量Exhaust volume> 1500 立方米/小>1,500 m3/ h过滤效率Filtration efficiency> 99.9%> 99.9%清理方式Clearance间歇式振动式清灰Vibrated cleaning振动电机功率Vibrated motor power150瓦(380 伏 / 50 Hz)150W (380V / 50 Hz)结构形式Structure圆筒形Cylinder直径Diameter800 mm800 mm安装高度Installation height1655mm1655mm连接方式Connections卡箍连接(含密封圈)Clamps (including seal)桶体材料Body material碳钢Carbon Steel喷漆颜色Paint color黄色Gray / Yellow (optional)重量Weight100kg100kg 二、滤芯清洗方式每6 个月一次, 取出滤芯进行清洗。Once every six Remove filter cleaning.清洗可采用压缩空气或者高压蒸汽(温度不得超过80 0C),Use compressed air or high pressure steam cleaning(the maximum temperature of over 80 0C).在滤芯外侧40 厘米距离处进行喷洗。从滤芯顶部慢慢移向底部。In the filter lateral distance of 40 cm for jet washing.Gradually shift from the top of the bottom of the filter.清洗结束后, 将滤芯开口朝下以便水份流出。After washing, opening facing down so that water willfilter out.室温下放置约一周待其晾干。Once dry place at room temperature for about a week.或者在烘箱内(温度不得超过80 0C)烘大约20 小时可干。Or in the oven (the maximum temperature of over 800C) to try to be out of work for about 20 hours. 三、. 维护Maintenance每 3 个月一次, 检查除尘器内部的洁净部位是否有粉尘出现;如果出现粉尘, 则:1. 检查滤芯是否破损;2. 检查密封部位;3. 检查滤芯是否正确安装在安装板上。Once every three months to checkwhether a dust precipitator internalparts of the cleanliness there.If dust :1. Check whether the damaged filter;2. Seal inspection sites;3. Check whether the correct installation ofthe filter installed board.